Main Page

From NPrize
Revision as of 02:23, 5 January 2010 by Vincent (talk | contribs) (add N-Prize internal link)
Jump to navigationJump to search

N-Prize reflexion wiki

This web site aims to gather to gather my researches in the field of astronautics, rocketry and other launch technologies that can be used for the N-Prize competition. It is not an official web site for the N-Prize. The official web site is here: http://www.n-prize.com/ . I'm not part of a team, nor did I register a team, because I don't really have the expertise to actually build it in time before the deadline of the project in september 2011.

How to escape from Earth?

Rockets have been used for 50 years to escape the gravity of earth. They are good for two things: go fast and burn a lot of ergols. Indeed, the efficiency of a propulsion engine is measured with a specific impulse (I_sp), and for rocket engines, it is quite low. However, they are the only engines that provide the sufficient thrust to climb up with large speeds.

Besides altitude, speed is the most important factor when orbiting an object. Without it, satellites would fall down on Earth, even if you climb up at 200 miles. Once again, rocket engines, with their high thrust power can achieve sufficient speed before falling back on Earth.

Rocket trajectories generally roughly form a square angle, while the final direction of the flight is parallel to Earth's surface. The reason is that since they achieve ultra-sonic speeds very quickly, the air pressure on their body (mainly the fairing) is quite important. It is more efficient to first escape the atmosphere and then change trajectory to gain the horizontal speed needed for orbital injection.

That particular point of the cost of escaping the atmosphere made me thought about using an aircraft to launch a rocket from the upper atmosphere, reducing considerably the air pressure, the drag, and improving trajectory and efficiency. Moreover, the specific impulse of a turbo-propeller is around ten times greater than the Isp of a rocket engine, since it uses oxygen from the atmosphere to burn its fuel, and not some embedded oxydizer. The fact that it uses a turbo design is also part of the improvement. For the N-Prize, the cost of the aircraft could be deducted from the overall price since it would be reused.

I started searching, and I found out that Orbital already has developped an air-to-orbit vehicle, called the Pegasus. It is able to orbit a payload up to 1,000 lbs (450 kg), and is launched from a full-sized airplane. My goal is thus to study the feasability of something similar, at low price, even for the aircraft because I am not a millionaire. A rocket would still be used for air-to-orbit link because nothing else is able to achieve speeds around 9 km/s. Some specific technologies can be used to improve efficiency, we'll see them below in the rocket section.

Several teams are working on using Helium balloons to get to the high atmosphere, around 70km and then launch a rocket. It is a nice solution too, and less expensive in the overall, but balloons are not reusable and suffer from imprecise position localization due to winds.

The aircraft

Some aircrafts have been exploring the high atmosphere, around 30km high. Contrary to what one would assume, high flight speeds are not needed. The Helios for example, flights at this altitude at 20km/h. Nevertheless, we would benefit from high speeds of the aircraft, speed that wouldn't be needed by the rocket to reach.

Fuel or electricity? Kerozene or alcohol?

How to build a £100 turbo-propeller?

Staging

Separation from the rocket is a big concern. If wings are directly mounted on the rocket body and jettisoned, they would not need some guidance or attitude control electronics, just a basic parachute system. If the wings are able to fly without the rocket, two guidance systems are needed: one for the rocket and one to get back the aircraft in one piece.

The rocket

Fuel

Ergols represent the most important part of the weight of what we have to launch. It should thus be chosen carefully regarding to its cost.

Alcohol has been used in the early ages of rocketry, in the german V-2 for examples. It has the advantages to be cheap, and burns quite well. It is not pure, generally used between 75 an 90 percent of volume ratio with water for the rest. The loss of weight due to that water is often a good thing because it burns producing so much heat that the water can keep the engine cool enough to survive. Rocket-grade kerozene (RP-1) has been introduced later to replace alcohol, providing a beter volume efficiency.

To my eyes, alcohol seems to be a very good low cost solution. RP-1 is still used nowadays, and is only 20% more efficient than alcohol with a liquid oxygen (LOX) oxydizer. The next question is thus: should we use some pure alcohol, alcohol/water blend or alcohol/something else blend?

I believe that E85, a 85 percent alcohol and 15 percent gasoline fuel recently used in automotive, is promising. I think that it's efficiency will be slightly better than alcohol, still being very cheap, around £0.5 a liter.

Trajectory

The trajectory has to be precise enough to get a launch authorization for a specific orbit. I believe that simple cameras can be used on the rocket to determine position of the sun and the Earth's horizon. Accelerometers, digital gyroscopes and a compass are really cheap nowadays and can be used too.

Anyway, if sensors are available, actuators are different story. I see only two possibilities, as fins won't have any impact in the vacuum of space: the rocket engine has to be directionally controllable or control jets must be used to control the attitude of the rocket. Both case imply lot of complications of the rocket's hardware.

The satellite

Lots of strategies for the tracking of the satellite have been exposed: flashing device, radioactive, narrowband EM emitting, mirrors...